A Review on The Enhancement of Biogas Production Through  Pre-Treatment of Domestic Wastewater Sludge  for Methane Gas Utilization

Almalita Mardiah; Nopa Dwi Maulidiany

Authors

Almalita Mardiah Universitas Indonesia Author
Nopa Dwi Maulidiany Universitas Indonesia Author

Keywords:

sewage sludge, anaerobic digestion, methane yield optimization, sludge conditioning, biosolids management

Abstract

Anaerobic Digestion (AD) is a prevalent and cost-effective method for managing domestic wastewater sludge, often accounting for 20–60% of plant operational costs. This process supports the circular economy by converting organic matter in Waste Activated Sludge (WAS) into renewable biogas. However, WAS is notoriously resistant to degradation due to complex compounds, such as lignocellulose and Extracellular Polymeric Substances (EPS), which severely impede hydrolysis. Therefore, pre-treatment is essential to modify the sludge structure, solubilise organics, accelerate hydrolysis, and enhance methane production. This systematic literature review, conducted according to the PRISMA Checklist 2020, analyses the effectiveness of various pre-treatment methods (mechanical, chemical, physico-chemical, biological, and combined) on domestic sludge. The review found that methane production enhancement varied widely, from 0% to an exceptional 524%, depending on the method and operational parameters. Significantly, combined techniques, such as High-Pressure Homogenisation (HPH) paired with Free Nitrous Acid (FNA), achieved the highest reported increase in methane yield, reaching 524%.

References

[1] X. Yang et al., “Enhanced hydrolysis of waste activated sludge for methane production via anaerobic digestion under N2-nanobubble water addition,” Sci. Total Environ., vol. 693, p. 133524, 2019, doi: 10.1016/j.scitotenv.2019.07.330.

[2] S. M. Wandera, W. Qiao, M. Jiang, A. Mahdy, D. Yin, and R. Dong, “Enhanced methanization of sewage sludge using an anaerobic membrane bioreactor integrated with hyperthermophilic biological hydrolysis,” Energy Convers. Manag., vol. 196, no. May, pp. 846–855, 2019, doi: 10.1016/j.enconman.2019.06.054.

[3] L. Appels, J. Baeyens, J. Degrève, and R. Dewil, “Principles and potential of the anaerobic digestion of waste-activated sludge,” Prog. Energy Combust. Sci., vol. 34, no. 6, pp. 755–781, 2008, doi: 10.1016/j.pecs.2008.06.002.

[4] Q. Zhang, J. Hu, D. J. Lee, Y. Chang, and Y. J. Lee, “Sludge treatment: Current research trends,” Bioresour. Technol., vol. 243, pp. 1159–1172, 2017, doi: 10.1016/j.biortech.2017.07.070.

[5] A. Gherghel, C. Teodosiu, and S. De Gisi, “A review on wastewater sludge valorisation and its challenges in the context of circular economy,” J. Clean. Prod., vol. 228, pp. 244–263, 2019, doi: 10.1016/j.jclepro.2019.04.240.

[6] A. Qarani and M. Sabah, “Wastewater sludge characteristics, treatment techniques and energy production,” Reciklaza i Odrziv. Razvoj, vol. 15, no. 1, pp. 9–26, 2022, doi: 10.5937/ror2201009a.

[7] S. Zahedi, P. Icaran, Z. Yuan, and M. Pijuan, “Assessment of free nitrous acid pre-treatment on a mixture of primary sludge and waste activated sludge: Effect of exposure time and concentration,” Bioresour. Technol., vol. 216, pp. 870–875, 2016, doi: 10.1016/j.biortech.2016.06.038.

[8] M. Nabi, D. Gao, J. Liang, Y. Cai, and P. Zhang, “Combining high pressure homogenization with free nitrous acid pretreatment to improve anaerobic digestion of sewage sludge,” J. Environ. Manage., vol. 318, no. June, p. 115635, 2022, doi: 10.1016/j.jenvman.2022.115635.

[9] D. Mignogna, M. Szabó, P. Ceci, and P. Avino, “Biomass Energy and Biofuels: Perspective, Potentials, and Challenges in the Energy Transition,” Sustain., vol. 16, no. 16, pp. 1–33, 2024, doi: 10.3390/su16167036.

[10] G. Zhen, X. Lu, H. Kato, Y. Zhao, and Y. Y. Li, “Overview of pretreatment strategies for enhancing sewage sludge disintegration and subsequent anaerobic digestion: Current advances, full-scale application and future perspectives,” Renew. Sustain. Energy Rev., vol. 69, no. November 2016, pp. 559–577, 2017, doi: 10.1016/j.rser.2016.11.187.

[11] X. Liu, Q. Wang, Y. Tang, and S. G. Pavlostathis, “Hydrothermal pretreatment of sewage sludge for enhanced anaerobic digestion: Resource transformation and energy balance,” Chem. Eng. J., vol. 410, no. July 2020, p. 127430, 2021, doi: 10.1016/j.cej.2020.127430.

[12] A. G. Calderon et al., “Enhancing anaerobic digestion using free nitrous acid: Identifying the optimal pre-treatment condition in continuous operation,” Water Res., vol. 205, no. April, p. 117694, 2021, doi: 10.1016/j.watres.2021.117694.

[13] S. Zahedi, F. Ferrari, G. Blandin, J. L. Balcazar, and M. Pijuan, “Enhancing biogas production from the anaerobic treatment of municipal wastewater by forward osmosis pretreatment,” J. Clean. Prod., vol. 315, no. May, p. 128140, 2021, doi: 10.1016/j.jclepro.2021.128140.

[14] S. Suthar, B. Sharma, K. Kumar, J. Rajesh Banu, and V. K. Tyagi, “Enhanced biogas production in dilute acid-thermal pretreatment and cattle dung biochar mediated biomethanation of water hyacinth,” Fuel, vol. 307, no. June 2021, p. 121897, 2022, doi: 10.1016/j.fuel.2021.121897.

[15] S. Mirmasoumi, S. Ebrahimi, and R. K. Saray, “Enhancement of biogas production from sewage sludge in a wastewater treatment plant: Evaluation of pretreatment techniques and co-digestion under mesophilic and thermophilic conditions,” Energy, vol. 157, pp. 707–717, 2018, doi: 10.1016/j.energy.2018.06.003.

[16] M. Hodaei, S. Ghasemi, A. Khosravi, and M. Vossoughi, “Effect of the ozonation pretreatment on biogas production from waste activated sludge of tehran wastewater treatment plant,” Biomass and Bioenergy, vol. 152, no. July, p. 106198, 2021, doi: 10.1016/j.biombioe.2021.106198.

[17] N. Machhirake, D. Singh, B. R. Yadav, M. Tembhare, and S. Kumar, “Optimizing alkali-pretreatment dosage for waste-activated sludge disintegration and enhanced biogas production yield,” Environ. Res., vol. 252, no. P2, p. 118876, 2024, doi: 10.1016/j.envres.2024.118876.

[18] R. Zeynali et al., “Sustainable enhancement of biogas production from a cold-region municipal wastewater anaerobic digestion process using optimized sludge-derived and commercial biochar additives,” J. Clean. Prod., vol. 478, no. October, p. 143948, 2024, doi: 10.1016/j.jclepro.2024.143948.

[19] H. E. Gulsen Akbay, N. Dizge, and H. Kumbur, “Evaluation of electro-oxidation and Fenton pretreatments on industrial fruit waste and municipal sewage sludge to enhance biogas production by anaerobic co-digestion,” J. Environ. Manage., vol. 319, no. July, p. 115711, 2022, doi: 10.1016/j.jenvman.2022.115711.

[20] W. Ren, Y. Zhang, X. Liu, S. Li, H. Li, and Y. Zhai, “Peracetic acid pretreatment improves biogas production from anaerobic digestion of sewage sludge by promoting organic matter release, conversion and affecting microbial community,” J. Environ. Manage., vol. 349, no. August 2023, p. 119427, 2024, doi: 10.1016/j.jenvman.2023.119427.

[21] N. A. Perendeci, A. S. Ciggin, E. Kökdemir Ünşar, and D. Orhon, “Optimization of alkaline hydrothermal pretreatment of biological sludge for enhanced methane generation under anaerobic conditions,” Waste Manag., vol. 107, pp. 9–19, 2020, doi: 10.1016/j.wasman.2020.03.033.

[22] Q. Deng, Y. Huang, P. Xian, T. Li, S. He, and Q. Liu, “Optimization of thermo-alkaline pretreatment on municipal sludge and enhanced subsequent anaerobic digestion,” Desalin. Water Treat., vol. 148, pp. 88–94, 2019, doi: 10.5004/dwt.2019.23712.

[23] H. E. Gulsen Akbay, N. Dizge, and H. Kumbur, “Enhancing biogas production of anaerobic co-digestion of industrial waste and municipal sewage sludge with mechanical, chemical, thermal, and hybrid pretreatment,” Bioresour. Technol., vol. 340, no. July, p. 125688, 2021, doi: 10.1016/j.biortech.2021.125688.

[24] Q. Zeng, F. Zan, T. Hao, S. K. Khanal, and G. Chen, “Sewage sludge digestion beyond biogas: Electrochemical pretreatment for biochemicals,” Water Res., vol. 208, no. November 2021, p. 117839, 2022, doi: 10.1016/j.watres.2021.117839.

[25] Z. Li et al., “Pretreatment of sludge with sodium iron chlorophyllin-H2O2 for enhanced biogas production during anaerobic digestion,” Environ. Res., vol. 204, no. PC, p. 112223, 2022, doi: 10.1016/j.envres.2021.112223.

[26] V. Toutian, M. Barjenbruch, C. Loderer, and C. Remy, “Impact of process parameters of thermal alkaline pretreatment on biogas yield and dewaterability of waste activated sludge,” Water Res., vol. 202, no. July, p. 117465, 2021, doi: 10.1016/j.watres.2021.117465.

[27] F. laqa Kakar, N. Purohit, F. Okoye, S. N. Liss, and E. Elbeshbishy, “Combined hydrothermal and free nitrous acid, alkali and acid pretreatment for biomethane recovery from municipal sludge,” Waste Manag., vol. 131, no. July, pp. 376–385, 2021, doi: 10.1016/j.wasman.2021.06.021.

[28] B. Shrestha et al., “A review of pretreatment methods to enhance solids reduction during anaerobic digestion of municipal wastewater sludges and the resulting digester performance: implications to future urban biorefineries,” Appl. Sci., vol. 10, no. 24, pp. 1–28, 2020, doi: 10.3390/app10249141.

[29] G. C. Mitraka, K. N. Kontogiannopoulos, M. Batsioula, G. F. Banias, A. I. Zouboulis, and P. G. Kougias, “A Comprehensive Review on Pretreatment Methods for Enhanced Biogas Production from Sewage Sludge,” Energies, vol. 15, no. 18, 2022, doi: 10.3390/en15186536.

[30] I. Volschan Junior, R. de Almeida, and M. C. Cammarota, “A review of sludge pretreatment methods and co-digestion to boost biogas production and energy self-sufficiency in wastewater treatment plants,” J. Water Process Eng., vol. 40, no. June 2020, p. 101857, 2021, doi: 10.1016/j.jwpe.2020.101857.

[31] S. Pilli, S. Yan, R. D. Tyagi, and R. Y. Surampalli, “Critical Reviews in Environmental Science and Technology Thermal Pretreatment of Sewage Sludge to Enhance Anaerobic Digestion : A Review,” Ecrit. Rev. Environ. Sci. Technol., vol. 45, no. 6, pp. 669–702, 2015, doi: 10.1080/10643389.2013.876527.

[32] M. Fioreze, L. Labotić, C. M. M. E. Torres, and C. M. Silva, “Effects of pretreatments on the solubilization and theoretical methane production of waste activated sludge from a Brazilian eucalyptus kraft pulp mill,” BioResources, vol. 17, no. 3, pp. 5300–5318, Jul. 2022, doi: 10.15376/biores.17.3.5300-5318.

[33] R. Dewil, L. Appels, J. Baeyens, and J. Degrève, “Peroxidation enhances the biogas production in the anaerobic digestion of biosolids,” J. Hazard. Mater., vol. 146, no. 3, pp. 577–581, 2007, doi: 10.1016/j.jhazmat.2007.04.059.

[34] P. Neumann, S. Pesante, M. Venegas, and G. Vidal, “Developments in pre-treatment methods to improve anaerobic digestion of sewage sludge,” Rev. Environ. Sci. Biotechnol., vol. 15, no. 2, pp. 173–211, 2016, doi: 10.1007/s11157-016-9396-8.

[35] G. Kor-Bicakci and C. Eskicioglu, “Recent developments on thermal municipal sludge pretreatment technologies for enhanced anaerobic digestion,” Renew. Sustain. Energy Rev., vol. 110, no. April, pp. 423–443, 2019, doi: 10.1016/j.rser.2019.05.002.

[36] D. Lima, G. Appleby, and L. Li, “A Scoping Review of Options for Increasing Biogas Production from Sewage Sludge: Challenges and Opportunities for Enhancing Energy Self-Sufficiency in Wastewater Treatment Plants,” Energies, vol. 16, no. 5, 2023, doi: 10.3390/en16052369.