Optimalisasi Kapasitas Baterai 110 Volt DC di Gardu Induk 150 kV Dawuan : Studi Kualitatif Berdasarkan Pengujian Lapangan

Oklim Pahotreski Sidabutar

Authors

Oklim Pahotreski Sidabutar Universitas Pembangunan Panca Budi Author

Keywords:

Baterai 110 Volt DC, , gardu induk, optimalisasi kapasitas, sistem proteksi, efisiensi energi

Abstract

The 110-Volt DC battery system plays a critical role in ensuring the reliability of protection and control systems at substations, including the 150 kV Dawuan Substation. However, in practice, suboptimal battery capacity is often encountered due to aging, excessive load, or insufficient routine maintenance. This study aims to analyze the actual performance of the installed battery bank, evaluate the efficiency of charging and discharging processes, and propose an optimization strategy to ensure the batteries operate at maximum effectiveness in accordance with operational standards. The methodology includes direct field measurements, historical data analysis, and simulation of DC load requirements under both normal and emergency conditions. The analysis results indicate significant capacity degradation from nominal values, which poses risks to the integrity of critical protection systems. By implementing cell rejuvenation techniques, load balancing, and reconfiguration of the charging system, battery capacity was successfully restored to approximately 95% of its ideal condition. This optimization is expected to extend battery service life and enhance the reliability of control systems at Dawuan Substation.

References

[1] D. S. P. Supari, Optimalisasi Listrik Tenaga Surya dalam Mobilitas Perahu. Malang: PT. Literasi Nusantara Abadi Grup, 2024.

[2] S. Fajri and P. Wibowo, “Analysis of Transformer Turn Ratio Test Results on 60 MVA Power Transformer at Simpang Tiga Substation PT . PLN ( Persero ) ULTG Prabumulih,” vol. 7, pp. 1–10, 2025, doi: 10.52005/fidelity.v7i1.260.

[3] I. Nurhadi and Liliana, “Pengaruh Temperatur dan Nilai Berat Jenis Cairan Elektrolit Terhadap Tegangan Sel Baterai Nickel Cadmium 110 VDC Gardu Induk Perawang Sistem 150 KV,” Cyclotr. J. Tek. Elektro, vol. 5, no. 02, pp. 14–19, 2022.

[4] I. P. Tama, O. Novareza, D. Hardiningtyas, R. Yuniarti, and N. F. Nuzula, Potensi Masa Depan Elektrifikasi Kendaraan Bermotor di Indonesia: Sebuah Analisis Strategis Rantai Pasok. Malang: UB Press., 2023. doi: 10.11594/ubpress9786232967663.

[5] H. Rusiana Iskandar et al., “Analisis Performa Baterai Jenis Valve Regulated Lead Acid Pada PLTS Off-Grid 1 Kwp,” J. Teknol., vol. 13, no. 2, pp. 129–140, 2021.

[6] M. R. Pratama, P. Wibowo, and A. P. Tarigani, “Analysis of Insulation Resistance Testing During Biennial Maintenance of 20 kV Incoming Cubicle Circuit Breakers at Gunung Megang Substation , PT PLN ( Persero ) ULTG Prabumulih UPT Baturaja,” vol. 7, 2025.

[7] C. N. Karimah, “Analisa Baterai Sebagai Sumber Kelistrikan Kendaraan Roda Dua Ditinjau Dari Kapasitas Dan Efisiensi,” J. Tek. Terap., vol. 2, no. 1, 2023, doi: 10.25047/jteta.v2i1.24.

[8] N. Putra Nabahan, S. Suryanto, and N. Hamzah, “Simulasi Temperatur dan Performa Panel PV dengan Pendinginan Vakum Menggunakan Ansys dan Matlab,” J. Tek. Mesin Sinergi, vol. 22, no. 1, pp. 77–89, 2024, doi: 10.31963/sinergi.v22i1.4947.

[9] S. diah ayu Febriani, “Analisis Tekno Ekonomi Pemasangan PLTS Rooftop On Grid 120 Kw (Studi Kasus PLTS di PT Santinilestari Energi Indonesia),” J. Tek. Terap., vol. 2, no. 2, 2024, doi: 10.25047/jteta.v2i2.31.

[10] A. D. T. Ariyanto Gultom, Parlin Siagian, “An Improved Protection Of High Voltage Air Line Using Differential Relays,” J. Sci., vol. 13, no. 03, pp. 673–684, 2024.

[11] A. Nurwanto, “Rancang Bangun Pembangkit Listrik Tenaga Surya (Plts) Dengan Sistem Kontrol Automatic Transfer Switch (Ats) Dan Optimalisasi Kapasitas Baterai,” J. Elektro dan Inform. Swadarma, vol. 3, no. 1, pp. 22–30, 2023.

[12] Satria Darmawan, “Analisis Perbandingan Kinerja Pembangkit Listrik Tenaga Surya dan Pembangkit Listrik Tenaga Uap pada Lingkungan PT. RAPP,” J. Engine, vol. 8, no. 2, 2024, doi: https://doi.org/10.30588/jeemm.v8i2.1960.

[13] H. Sirait, “Sistem Pelacak Sinar Matahari Dalam Pengisian Daya Listrik Pada Accu Menggunakan Solar Panel,” Semnastikom, vol. 1, pp. 28–31, 2016.

[14] F. Anis, D. Lesmana, and P. Siagian, “Analisis Pengaruh Pemeliharaan Preventif Jaringan Distribusi 20kV Pada Penyulang Gu . 03 Terhadap Indeks Keandalan Jaringan di PT . PLN ( Persero ) ULP Medan Timur,” vol. IX, no. 4, pp. 10431–10443, 2024.

[15] H. Susiati et al., Pembangkit Listrik Tenaga Nuklir di Indonesia (Upaya Berkelanjutan Menuju Net Zero Emission), no. May. 2023.

[16] D. S. A. Raysi, N. P. Dwi, Soedarmanto, and M. H. E. Kalangi, “Optimalisasi Penerapan E-RTG pada RTG Konvensional di Terminal Petikemas Nilam,” J. Adm. Bisnis, vol. 1, no. 1, pp. 1–17, 2024.

[17] Susy Susanti, “Digital Transformation at PLN Jambi: Improving Operational Efficiency and Costumer Satisfaction through Manajement Information Systems,” Media J. Account. Manag., vol. 1, no. 1, 2024.

[18] M. Z. S. Akbar and S. R. Riady, “Sistem Akuisisi Dan Monitoring Performa Mesin Produksi Berbasis Internet of Things (IoT) Dengan Metode Logging Data,” J. Mhs. Bina Insa., vol. 7, no. 1, pp. 55–64, 2022.

[19] N. S. Saragih, P. Siagian, and M. Fahreza, “Analisis Jaringan Listrik 20 Kv Berdasarkan Nilai Saidi-Saifi Terhadap Pemasangan Tabung Urgent Cut Out Di Pt. Pln (Persero) Ulp Binjai Timur,” Power Elektron. J. Orang Elektro, vol. 13, no. 1, pp. 46–51, 2024, doi: 10.30591/polektro.v13i1.6545.

[20] M. Ridho, P. Siagian, Z. Tharo, U. Pembangunan, and P. Budi, “Terhadap Kinerja Sistem Proteksi Gardu Induk 150 KV,” vol. 12, no. 3, 2024.

[21] Y. S. Aritonang, P. Siagian, and S. Aryza, “Teknologi Tinggi Ultra High Voltage Untuk Keandalan Efisiensi Energi ( Sebuah Tinjauan Literatur ),” vol. 12, no. 3, 2024.

[22] PT.PLN (Persero), “Buku Pedoman Pemeliharaan Primer Gardu Induk,” in Kepdir No.0520- 2.K DIR, 2014.